Proptec: Series PT100 Air-Assisted Atomizers

Hydraulic-powered, requires 2-4 GPM, variable adjustable airflow from zero to 10,000 CFM (275 cubic meters per minute), variable fluid flow from zero to 3.5 gallons per minute (0-13 LPM). Shown with six-inch, #12 mesh basket. Operating speed between 2500 and 5000 RPM.

• Model Shown: PT100-35-0200-A
• Similar Series : PT50 Hydraulic Drive
• Common Uses: Pesticide application, high-volume mist creation, dust control, odor control, right-of-way management, wastewater elimination, wastewater evaporation, mobile applications.

Proptec: Series PT098 Coarse-Droplet Atomizers

Large droplet atomizer by Proptec, non-air-assisted. Creates a radial spray pattern of approximately 250 to 1000 micron or larger droplets. Can range from 500 to 6000 RPM operating speed. These models are nearly impossible to clog, with quiet operation.

• Model Shown: PT098-25-0000-A
• Similar Series: PT48 Hydraulic Drive, PT199 Electric Motor
• Common Uses: Applications requiring larger drops and a radial spray pattern, or where clogging is a problem.

Proptec: Series PT099 Fine-Droplet Atomizers

Fine droplet atomizer by Proptec, non-air-assisted. This atomizer creates a radial spray pattern of very fine droplets of approximately 45 to 150 micron depending on the specific configuration and speed. Can range from 500 to 6000 RPM operating speed. Quiet operation.

• Model Shown: PT099-25-0200-A
• Similar Series: PT49 Hydraulic Drive, PT200 Electric Motor
• Common Uses: Spraying in stacks or other columnal flows, humidification in plenums when a droplet collector is installed downstream, any other chemical or manufacturing process that requires a radial spray pattern.

Proptec: Series PT099 and PT200 Atomizers (Humidifying Applications)

2-stage atomizers with 12" baskets for higher volumes and finer mists at lower speeds than standard 6-inch baskets. Flow rates to two gallons per minute and up (7.5 LPM), for humidification rates to 120 gallons per hour, per atomizer. That's serious misting!

• Models Shown: PT099-20-2230-A (Hydraulic) and PT200-20-2230 (Electric)
• Similar Series: PT49 Hydraulic Drive
• Common Uses: Spraying in stacks or other columnar flows, humidification in plenums, open-area cooling (humidification) patios, greenhouses, cold storages, any other chemical or manufacturing process that requires a radial spray pattern of extremely fine droplets.

Proptec: PT200 Atomizers (Humidifying Applications / Low Flows)

Demonstrates a flow rate of approximately .25 GPM through the 12-inch basket. Features hydraulic and electric non-air-assist atomizers with the 12-inch basket, creating finer mists at lower speeds than the standard 6-inch baskets.

• Model Shown: PT200-20-2230 (Electric)
• Similar Series: PT49 Hydraulic Drive
• Common Uses: Spraying in stacks or other columnar flows, humidification in plenums, open-area cooling (humidification) patios, greenhouses, cold storages, any other chemical or manufacturing process that requires a radial spray pattern of extremely fine droplets.

Proptec: PT200 Atomizers (Humidifying Applications / High Flows)

Demonstrates flow rates in excess of 1 GPM through the 12-inch basket; maximum rated flow for the PT200 series. Features hydraulic and electric non-air-assist atomizers with the 12-inch basket, creating finer mists at lower speeds than the standard 6-inch baskets.

• Model Shown: PT200-20-2230 (Electric)
• Similar Series: PT49 Hydraulic Drive
• Common Uses: Spraying in stacks or other columnar flows, humidification in plenums, open-area cooling (humidification) patios, greenhouses, cold storages, any other chemical or manufacturing process that requires a radial spray pattern of extremely fine droplets.

Proptec: Series PT200 Atomizers (Air-Assist and No Air-Assist Electrical Motor)

Features hydraulic and electric non-air-assist atomizers with 12-inch basket. Larger basket creates higher volumes and finer mists at lower speeds than standard 6-inch baskets. Flow rates to two gallons per minute (7.5 LPM), for humidification rates to 120 gallons per hour, per atomizer.

• Model Shown: PT215-20-2230 (Electric) and Various Versions of the PT200
• Similar Series: Most air-assist applications can be duplicated with the PT100 and PT50 hydraulic atomizers.
• Common Uses: Spraying in stacks or other columnar flows, humidification in plenums, open-area cooling (humidifying) patios, greenhouses, cold storages, any other chemical or manufacturing process that requires a radial spray pattern.

Proptec: Six-Head T-Boom (Trailed)

Precise spray application with drift containment on heavy Geneva Double-Curtain canopy. Cover two rows per pass at 3.5 mph the entire season, with over 6.5 acres per hour of actual productivity. Can spray three or four rows in early season by tipping outer heads outward.

• Crop: Double-Curtain Delaware Grapes (25 GPA)
• Location: Widmer Winery, Naples, New York
• Owner: Canandaigua Brands

Proptec: Eight-Head Vertical Tower (Trailed)

Demonstrates a Proptec orchard tower, properly set up with heads above trees and spraying slightly down, effectively covers and contains overspray; allowing spray to travel through one row to the next. Gets two full rows per pass at 4 miles-per-hour, resulting in over 15 acres per hour of actual productivity.

• Crop: Apples (25 GPA)
• Location: Hy's Cider Mill, Romeo, Michigan
• Owner: Jim Goldstein

Proptec: Four-Head Vertical with Backlit Night Footage (Trailed)

Actually SEE the spray with backlit footage- you wont beieve its only 10 GPA. An outstanding characterization of the turbulence and canopy penetration possible with Proptec sprayers. The spray fully penetrates the first row, and then the second row as well. Drift is contained, and two rows per pass can be achieved for entire season.

• Crop: Vertical Shoot-Positioned Chardonnay (10 GPA)
• Location: Chateau Chantal, Mission Peninsula, Michigan
• Owner: Charlie Edson, Bel Lago Winery

Proptec: Four-Head T-Boom (Trailed)

A cloud is created, covering both sides of vine with one pass without dropper booms. Four-head versions are best for lighter canopies, or with smaller tractors. Gets two rows per pass the entire season. Can spray four rows in the early season by tipping the outer heads outward.

• Crop: Single-Cordon Hybrid Grapes (10 GPA)
• Location: Clearview Farms, Branchport, New York
• Owner: Tones Brothers

Hagie: 2100 High-Clearance Self-Propelled Sprayer (Proptec Boom)

Outstanding disease control of late blight in carrots and potatoes, with 5 GPA and copper. Reduced phomopsis loss in cucurbits by over 15% when compared to nozzle sprayer. Excellent for nursery crops. Booms available to 90 feet.

• Crop: Carrots (5 GPA), Asparagus (10 GPA), Christmas Trees (10 GPA)
• Location: Oceana County, Michigan
• Refitters: Michigan State University Engineers

Proptec: Eight-Head Monoboom (Trailed)

The future of pome, bush and stonefruit spraying, with 93% reduction in drift. Gets two to four rows per pass at 5 mph, for 15-18 acres per hour of actual productivity — replacing up to three pull-type machines. High wind resistance, and clears fourteen feet.

• Crop: Second – Fourth Leaf Peaches (15-25 GPA)
• Location: USDA Fruit Tree and Nut Research Center, Byron, Georgia
• Owner: USDA Fruit Tree and Nut Research Center

Proptec: Eight-Head Monoboom (Trailed)

Similar to eight-head monoboom above, but shown in blueberries. Has high wind resistance, superior coverage, and productivity similar to cannon sprayers. Can spray over 150 acres per day. Tests show a 10 to 15 percent reduction on Alternaria and anthracnose losses compared to conventional sprayers.

• Crop: Blueberries (10 GPA)
• Location: Steve Paul Farms, Muskegon, Michigan

Proptec: Eight-Head Wrap-Around Boom (Trailed)

For superior coverage in high-value, highly ultra-low disease tolerant crops such as Icewine grapes or massive-canopied Thompson seedless grapes. Ground speeds of 4 mph result in 7.5 acres per hour of actual productivity or higher. Dropper booms turned outward cover four rows in early season for 15 acres per hour or more of actual productivity.

• Crop: Hybrid Grapes; Scott-Henry, Kniffen, VSP, Smart-Dyson Trellis (15 GPA)
• Location: Glenview Farms, Vineland, Ontario
• Owner: David Wiley

Proptec: Eight-Head Vertical Tower (Trailed)

A refit of an existing bean sprayer. This sprayer can handle up to 25 GPA at 3.5 miles-per-hour, which gives it excellent coverage in alternate middle-spraying. This low gallonage results in more acres sprayed before the tank needs filling; allowing for a much more productive time in the field.

• Crop: Montgomery (Tart) Cherries (25 GPA)
• Location: Michigan State University Northwest Horticultural Station
• Owner: Michigan State University Northwest Horticultural Station